Home
About Us
Calendar
Fiero Documents
Merchandise
Tips
Links
Members
Message Board
Other Fiero Clubs
VIN Decoder
Speed Calculator
GFC Facebook Page
 

Author Topic: Club's Formula Fastback  (Read 61909 times)

0 Members and 1 Guest are viewing this topic.

MikeMac

  • Newbie
  • *
  • Posts: 35
    • View Profile
Re: Club's Formula Fastback
« Reply #75 on: June 28, 2017, 05:27:53 pm »
On the bright side the clutch hydraulics seem to be functioning fine so we won't need a clutch slave.
I ran the engine for about 30 minutes today and it suddenly died just as if you had turned the ignition switch. It would crank over but not start until it cooled off. Maybe we can look at it after the July 8th club meeting.

Raydar

  • Paid Members
  • *****
  • Posts: 2,963
    • View Profile
Re: Club's Formula Fastback
« Reply #76 on: June 28, 2017, 08:29:32 pm »
I got the car running today and the miss is gone but it is idling high.
...

If something changed drastically, it may have changed the idle.
It needs to be driven at 30+ MPH to reset the IAC.
...

MikeMac

  • Newbie
  • *
  • Posts: 35
    • View Profile
Re: Club's Formula Fastback
« Reply #77 on: June 28, 2017, 09:41:51 pm »
I can drive it and it will be covered under my shop insurance policy. I will run it tomorrow and if it dies out I'll see if I've lost spark since the fuel system seems to be in order.

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #78 on: June 28, 2017, 11:02:08 pm »
The car was trying to quit and the fuel pump was howling the last time I drove it.  Discovered it was out of gas.  I only put 2 gallons in it, so you might want to make your first trip to the gas station.

Dieing after it builds up heat might be that the ICM is breaking down.  They can rejuvenate after they cool down.  You can still have spark but no fuel pump.  The pump will cycle when the key is turned on because that's a function of the ECM, but there won't be enough fuel to make it run. 
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: Club's Formula Fastback
« Reply #79 on: July 06, 2017, 05:07:44 pm »
So, what happened?

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #80 on: July 06, 2017, 05:24:04 pm »
Mike told me he has it all back together.  High rpm and no power.  We troubleshot it over the phone and he found a vacuum line on the bottom of the throttlebody had slipped off.  Replaced it and it idled down to a smooth 900 rpm.

I had put 5 more gallons of fuel in it when  I delivered  it to Mike's shop.  That quited the pump.
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: Club's Formula Fastback
« Reply #81 on: July 06, 2017, 05:45:12 pm »
Wouldn't that make you figure that the pump is bad?

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #82 on: July 06, 2017, 07:08:37 pm »
Originally it only had a few gallons in it after the pump install.  I occasionally drove it around the subdivision or started it to keep the engine running and to try to find the skip.  The fuel got so low that the pump wasn't submerged enough.  That's the reason for the howling. 
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: Club's Formula Fastback
« Reply #83 on: August 04, 2017, 12:25:10 am »
Is this one all good, now?

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #84 on: August 04, 2017, 07:27:04 am »
It had suddenly stopped running.  I went down and swapped out the ignition module, but that didn't help.  We also swapped out the pigtail from the coil to the module, but still no spark.  Mike's putting his spare time toward getting the Aerodonamic car up and going in time for Run For The Hills, so this one currently comes in 2nd. 
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: Club's Formula Fastback
« Reply #85 on: August 04, 2017, 07:35:43 am »
Ah.  Not that I doubt MikeMac's abilities, but I hope RFTH won't be the first excursion with the Aerodonamic car.

I haven't seen MikeMac post for a bit.  Probably busy working.

For the fastback, I hope the timing hasn't slipped.  Have to move up the wiring to check for spark.

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #86 on: August 04, 2017, 07:44:29 am »
Timing wouldn't affect spark.  We believe it may be the pickup coil. 

Mike has to replace the transmission on the Aerodonamic car.  Replacing a locked Isuzu with a Getrag. 
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GTRS Fiero

  • Hero Member
  • *****
  • Posts: 12,510
  • It is what it is.
    • View Profile
Re: Club's Formula Fastback
« Reply #87 on: September 20, 2017, 06:22:23 pm »
I don't recall seeing AeroDon's carr in the RFTH pics.  I haven't seen MikeMac post for a bit, either.

Will work resume on the fastback?

Fierofool

  • Global Moderator
  • *****
  • Posts: 10,565
    • View Profile
    • Georgia Fiero Club
Re: Club's Formula Fastback
« Reply #88 on: September 20, 2017, 08:37:38 pm »
MikeMac had been installing new tire and alignment machinery and he and his mechanic were taking some courses offered by O'Rielly Auto Parts.  Last I spoke with him, he hadn't had time to work on the AeroDonamic car.  That was the weekend before RFTH. 

The fastback had to take a back seat to everything, but we're going to be starting some tech days now that RFTH is out of the way. 

How about it, Pat and Ron, instead of having a meeting day and a separate tech day, what do you think of meeting at 10AM on our regular meeting day, and if Mike's available to let us into his shop for tech sessions, we can get the fastback and maybe his car up and going real soon.   
There are three kinds of men:

1.    The ones that learn by reading.
2.    The few who learn by observation.
3.    The rest of them have to pee on the electric fence and find out for themselves.    Will Rogers

GrannyLinda

  • Hero Member
  • *****
  • Posts: 667
  • I'm On The Right Track Baby, I WAS BORN THIS WAY !
    • View Profile
Re: Club's Formula Fastback
« Reply #89 on: September 20, 2017, 10:10:45 pm »
How about it, Pat and Ron, instead of having a meeting day and a separate tech day, what do you think of meeting at 10AM on our regular meeting day, and if Mike's available to let us into his shop for tech sessions, we can get the fastback and maybe his car up and going real soon. 

You Might Want To Check With Maria If It Is OK With Her Too.
I'm On The Right Track Baby !!!!
I WAS BORN THIS WAY !!!!